加入收藏| 关于我们 您好,欢迎来到济南金日和化工有限公司网站!

全国咨询热线:13386411819
0531-81762771

当前位置:首页>>新闻中心>>行业新闻>>氨基磺酸清洗水垢方法!
氨基磺酸清洗水垢方法!
来源:http://www.jnjrh.com 日期:2019-02-25 发布人:admin
氨基磺酸锅炉除垢剂为我公司传统产品,使用简单,无毒无味,不腐蚀锅炉。突出特点就是用也无法除掉的硫酸盐和硅酸盐水垢,用此除垢剂则有一定的效果,因此经销多年,深受欢迎。
  Aminosulfonic acid boiler descaling agent is our company's traditional products, simple to use, non-toxic, odorless, non-corrosive boiler. The prominent feature is the use of sulfate and silicate scale can not be removed, but the use of this scale remover has a certain effect, so it has been sold for many years and is very popular.
  (二) 除垢原理:  锅炉除垢剂主要是用碱类及碱性物质复配而成,成品为淡红色粉状。在锅炉内与硫
  (2) Principle of scale removal: Boiler scale removal agent is mainly composed of alkali and alkaline substances, and the finished product is pink. Sulphur in Boiler
  酸盐和硅酸盐水垢发生化学反应,生成碳酸盐类,这就是除垢剂能使坚硬难除的硫酸
  The chemical reaction between silicate scales and salts produces carbonates, which are sulphuric acid that is hard and difficult to remove by scale removers.
  盐水垢转型为疏松的水垢的道理。转型后的碳酸盐水垢不溶于水,但在转型中会从管壁上脱落下来或变酥松疏散,被除垢剂中的单宁物质分解为水渣,易于用手工或机械清除下来,从而达到除垢的目的。
  The reason why saltwater scale is transformed into loose scale. After transformation, carbonate scale is insoluble in water, but it will fall off the pipe wall or become loose and evacuated during transformation, and be decomposed into water slag by tannin substance in scale remover, which is easy to be removed by hand or machine, so as to achieve the purpose of scale removal.
  (三)使用方法:  除垢剂适用于工作压力≤13公斤/cm2,蒸发量低于4吨/时的无省煤器和过热器的锅炉。使用前先将除垢剂用80℃左右的热水溶解成20%浓度的溶液。然后给锅炉上水至***低可见水位,再把化开的溶液注入炉内,并保持高水位。而后点火升温、煮炉。煮炉的操作
  (3) Usage: The scale remover is suitable for boilers without economizer and Superheater whose working pressure is less than 13kg/cm2 and evaporation is less than 4t/h. Before use, the scale remover is dissolved into a 20% concentration solution in hot water at about 80 C. Then water is supplied to the boiler to *** low visible water level, and the boiled solution is injected into the furnace, and the high water level is maintained. Then ignition, heating, boiling furnace. Operation of Boiling Furnace
  分常压和带压两种方式。常压煮炉时,待炉水沸腾后,用小火保持炉水沸腾,炉内压力升至1公斤/cm2,后维持一段时间(维持时间不少于24小时)然后降压。煮炉停火后,要逐渐排污和补水,炉温要缓慢下降,以防造成残余应力,当炉水温度降至50℃左右方可放水。
  There are two ways: atmospheric pressure and pressure. When boiling at atmospheric pressure, the water is kept boiling in a small fire after boiling, and the pressure in the furnace rises to 1 kg/cm2, then maintains for a period of time (not less than 24 hours) and then lowers the pressure. After the stoppage of the boiling furnace, it is necessary to gradually discharge and replenish water. The temperature of the furnace should be slowly lowered to prevent residual stress. When the temperature of the boiling water drops to about 50 degrees Celsius, the water can be discharged.
  带压煮炉时,升压要缓慢,一般用24小时左右把压力升至工作压力的50%,然后保持该温度和压力,维护这种状态一段时间(维持时间不少于24小时)。煮炉时要昼夜连续运行,煮炉期间不要排污,也不要用气,以免影响效果,在煮炉期间要有专人值班,注意检查锅炉各部分及阀门有无漏泄现象。发现压力升高及其他异常,及时采取措施。煮炉之后,放完水及时打开人孔、毛孔、检查孔、用手工或压力水龙冲掉存在钢板上的水垢,否则泥垢还会重新硬化难于清除。
  When there is a pressure cooker, the pressure should be raised slowly. Generally, it takes about 24 hours to raise the pressure to 50% of the working pressure. Then the temperature and pressure should be maintained for a period of time (not less than 24 hours). Boiling furnace should be continuously operated day and night, during the boiling furnace do not sewage, do not use gas, in order to avoid affecting the effect, during the boiling furnace, there should be a special person on duty, pay attention to check the boiler parts and valves leakage phenomenon. When pressure rise and other abnormalities are found, timely measures should be taken. After boiling, open the manhole, pore, inspection hole in time, wash out the scales on the steel plate by hand or pressure hose, otherwise the scales will harden again and it will be difficult to remove.
  (四)用量:  碱性除垢剂的用量应根据水垢厚度加药。一般水垢1-2毫米厚,加药13-15公斤/吨水:水垢3-4毫米厚,加药15-17公斤/吨水;水垢5毫米以是时,加药17-19公斤/吨水;如果锅炉中水垢较厚,可加药到20-25公斤/吨水。
  (4) dosage: dosage of alkaline scale remover should be added according to the thickness of scale. Generally, scale is 1-2 mm thick, adding 13-15 kg/ton of water: scale is 3-4 mm thick, adding 15-17 kg/ton of water; scale is 5 mm, adding 17-19 kg/ton of water; if the boiler scale is thicker, adding medicine to 20-25 kg/ton of water.
 
  (五)注意事项  1. 煮炉期间加强值班,特别是带压煮炉时,不能离人,随时检查压力,防止除掉的垢块堵塞管线造成事故。   2.
  (5) Notes 1. Strengthen duty during boiling furnace, especially when boiling furnace with pressure, do not leave people, check pressure at any time to prevent accidents caused by blockage of pipelines caused by removed dirt blocks. 2.
  煮炉后,放完水,清除残垢,要检查水位表、汽水连通管、压力连接管、排污管等是否畅通,当无问题时,方可关闭人孔、毛孔、再投入运行。   3.
  After boiling, water is discharged and the residue is removed. It is necessary to check whether the water level meter, the steam-water connection pipe, the pressure connection pipe and the sewage discharge pipe are unblocked. When there is no problem, the manhole, the pore can be closed and put into operation again. 3.
  除垢剂属碱性物质,在配药和除垢过程中,要避免弄到皮肤和衣服上,一但弄上要及时清洗 。
  The scale remover belongs to alkaline substance. In the process of dispensing and scale removing, it is necessary to avoid getting on the skin and clothes, but once it is done, it should be cleaned in time.
  锅炉配件商店、锅炉配件门市、锅炉配件公司、水暖器材、锅炉厂、锅炉水暖安装、太阳能除垢剂、中央空调除垢剂,水垢过滤器,锅炉一般所指:蒸气锅炉、水暖锅炉、电锅炉、家用采暖锅炉等供热供暖供气设备,锅炉通过一段时间生产使用,锅炉内体水接触面生成的钙镁离子水垢(硅酸盐水垢、碳酸盐水垢、硫酸盐水垢),长时间不清洗水垢,对设备造成很大的危害,轻着锅炉本体烧不热,重着堵管道气体压力过大,出理重大事故(锅炉爆炸),使用我河北环球公司生产的锅炉“除垢剂”,根据水垢情况,一般每吨水加药五十至一百公斤,直接加放到水里寄可,本药剂固体颗粒见水就化,运输使用都很方便,清洗时间一般为五至八个小时基本上水垢处理完毕,水垢和药剂产生化学反应,慢慢溶解分解,不会堵塞管道出水孔,直接放出就可以,很简单。
  Boiler Parts Store, Boiler Parts Market, Boiler Parts Company, Water Heating Equipment, Boiler Factory, Boiler Water Heating Installation, Solar Energy Scale Remover, Central Air Conditioning Scale Remover, Scale Filter, Boiler General Reference: Steam Boiler, Water Heating Boiler, Electric Boiler, Household Heating Boiler and other heating and heating equipment, Boiler through a period of production and use, Boiler Body Water Contact Surface Calcium and magnesium ion scale (silicate scale, carbonate scale, sulfate scale) produced by the company does not wash the scale for a long time, which causes great harm to the equipment. Lightly burning the boiler body is not hot, the gas pressure is too high to block the pipeline, and serious accidents (boiler explosion) are dealt with. The boiler "scale remover" produced by Hebei Universal Company is used. According to the scale situation, generally every ton of water is used. Fifty to one hundred kilograms of medicine are added directly to the water to send it. The solid particles of the medicine will become instant in water. It is very convenient for transportation and use. The cleaning time is usually five to eight hours. The scale and the agent basically finish the scale treatment. The scale and the agent produce chemical reaction, dissolve and decompose slowly, and will not clog the outlet of the pipeline. It can be released directly. It is very simple.
  以上就是氨基磺酸的相关介绍,希望对您有所帮助,更多内容可以点击我们的官网进行咨询:http://www.jnjrh.com/
  This is the introduction of aminosulfonic acid. I hope it will be helpful to you. For more information, please click on our website: http://www.jnjrh.com./
相关标签:氨基磺酸